行业资讯
撒布车冬季维修保养不可不做的事项
来源：https://www.sddhfjx.com/ 日期：2023-03-22
入冬前，我们要对自己的爱车及时保养，使车辆以佳状态以备来年使用。今天，水泥撒布车出租人员就给大家的爱车进行“主动预防”，在冬季来临之前，给大家介绍一下车辆入冬后的保养小知识。
Before winter, we need to maintain our beloved car in a timely manner to keep it in good condition for use in the coming year. Today, the rental staff of the cement spreader truck will conduct "proactive prevention" for everyone's beloved car. Before winter comes, let's introduce some maintenance tips for the car after winter.
1、车辆入冬前，请检查管路的卡箍，由于热胀冷缩，防止卡箍变松，引起漏油、漏水、漏气及灰尘进入发动机；
1. Before the vehicle enters winter, please check the clamps of the pipeline. Due to heat expansion and cold contraction, prevent the clamps from becoming loose, causing oil, water, air, and dust to enter the engine;
2、及时检查副发动机防冻液是否符合当地的环境温度；如果有具备条件的，可用冰点仪测量下防冻液的冰点温度，发现冰点有所下降不适合车辆使用时应及时更换。冰点检测仪下的-40℃防冻液测量冰点检测仪下的-40℃防冻液测量
2. Timely check whether the auxiliary engine antifreeze meets the local ambient temperature; If conditions are met, the freezing point temperature of the antifreeze can be measured with a freezing point meter. If the freezing point is found to have decreased and is not suitable for vehicle use, it should be replaced in a timely manner. - 40 ℃ antifreeze measurement under the freezing point detector - 40 ℃ antifreeze measurement under the freezing point detector
3、注意副发动机机油的更换，及时更换适应当地气温的机油。防止由于机油粘度过大，影响发动机的冷启动。可根据使用说明书上的要求，添加适应当地低温度的机油。
3. Pay attention to the replacement of auxiliary engine oil, and timely replace the oil that adapts to the local temperature. Prevent cold starting of the engine due to excessive oil viscosity. Oil suitable for local low temperature can be added according to the requirements in the instruction manual.
4、提前选择能适应当地气候的燃油，避免燃油结蜡，堵塞油路，影响发动机的正常工作。
4. Select fuel that can adapt to the local climate in advance to avoid fuel waxing, blocking the fuel path, and affecting the normal operation of the engine.
5、水泥撒布车应存放于地势较高的位置，避免因雨雪天气而导致车辆被水浸泡。
5. The cement spreader should be stored at a high location to avoid soaking the vehicle in water due to rain and snow.
6、车辆入冬存放前务必要将车内的物料全部排空，均整器、软连接内残留物料与板结块必须全部清理干净。
6. Before storing the vehicle in winter, it is necessary to empty all the materials in the vehicle, and the residual materials and plate lumps in the equalizer and soft connection must be completely cleaned.
7、利用上人孔装过物料的，应对人孔处密封结构仔细检查，确保车辆密封良好，避免雨水进入。
7. If materials have been loaded through the upper manhole, the sealing structure at the manhole should be carefully inspected to ensure that the vehicle is well sealed and prevent rainwater from entering.
8、对水泥撒布车除尘系统检查，以确认除尘系统是否需要维护保养及更换配件。
8. Inspect the dust removal system of the cement spreader to confirm whether the dust removal system requires maintenance and replacement of accessories.
9、对车辆液压系统检查，以确认液压系统是否需要维护保养。
9. Inspect the vehicle's hydraulic system to confirm whether it requires maintenance.
工程机械的维修保养工作务必要细心，只有综合各方面的原因，才能迅速提升工作性能及工作效率，从根本上解决设备可能出现的故障或安全隐患，实现维修保养的战略目的。更多相关内容就来我们网站https://www.sddhfjx.com咨询！
The maintenance and repair work of construction machinery must be careful. Only by integrating various reasons can we quickly improve working performance and efficiency, fundamentally solve potential equipment failures or safety hazards, and achieve the strategic purpose of maintenance and repair. For more relevant content, please visit our website https://www.sddhfjx.com consulting service
公司地址：济南市槐荫区经一路273号群盛华城2号楼1-404
公司名称：山东途畅路桥工程有限公司 
备案号：