沥青水泥撒布车常见故障及解决方法！_行业资讯_新闻中心-山东途畅路桥工程有限公司

行业资讯

沥青水泥撒布车常见故障及解决方法！

来源：https://www.sddhfjx.com/ 日期：2020-11-30

沥青水泥撒布车常见故障及解决方法

Common faults and solutions of asphalt cement spreader

1.柴油机不能持续起动超过5秒钟以上，不能连续启动三次以上，三次不能起动应检查油路、电路。

1. If the diesel engine can not be started continuously for more than 5 seconds or more than three times, the oil circuit and circuit should be checked.

2.柴油机不起动，不能对沥青泵预热。

2. If the diesel engine does not start, the asphalt pump cannot be preheated.

3.充电显示灯红灯不亮表示发动机未对蓄电池充电，设备有故障，应对电路、电器进行检修。

3. If the red light of the charging indicator light is not on, it means that the engine has not charged the battery, and the equipment has fault. Therefore, the circuit and electrical appliances should be overhauled.

4.如启动机发生打滑现象，应调整启动机支架位置

4. If the starter slips, adjust the position of the starter bracket
水泥撒布车出租

5.离合器离、合过程中，拉动离合器手柄能使离合器可靠平稳地分离和结合，不得有卡滞打滑现象。调整离合器分离杠杆与分离轴承的间隙可通过调整离合器软轴拉线来实现。

5. In the process of clutch opening and closing, pulling the clutch handle can make the clutch separate and combine reliably and smoothly without jamming and slipping. The clearance between the clutch release lever and the release bearing can be adjusted by adjusting the clutch cable.

6.沥青泵转动开始还未喷沥青

6. Asphalt has not been sprayed since the asphalt pump started to rotate

调整发动机转速;

Adjust the engine speed;

检查沥青管路是否堵塞;

Check whether the asphalt pipeline is blocked;

沥青进油管路中有空气，可使沥青泵运转30秒钟后排完空气后吸油喷洒。

There is air in the asphalt oil inlet pipeline, which can make the asphalt pump run for 30 seconds and then absorb oil and spray after the air is finished.

上一条：冷再生机作业时的一些情况你知道吗？

下一条：冷再生机租赁公司是如何使用乳化沥青的呢？