公司新闻
水泥撒布车安全操作规程你知道多少？
来源：https://www.sddhfjx.com/ 日期：2020-08-10
1汽车部分按汽车安全操作规程的规定进行操作。
1. The automobile part shall be operated according to the regulations of automobile safety operation regulations.
2检查各操作部分、阀门、仪表、沥青泵液压系统等工作装置是否正常。
2 check whether the operating parts, valves, instruments, asphalt pump hydraulic system and other working devices are normal.
3检查防火器材及防护用品是否齐全有效。
3. Check whether the fire prevention equipment and protective equipment are complete and effective.
4严禁采用规定之外的燃油作为加热系统的燃油，不允许燃油溢出箱外，一般油面应低于溢流管上端20-30厘米。
4. It is strictly forbidden to use the fuel beyond the regulations as the fuel of the heating system, and it is not allowed to overflow the tank. Generally, the oil level should be 20-30cm lower than the upper end of the overflow pipe.
5使用固定式喷灯向沥青箱火管加热时，应先打开沥青箱后壁上的烟囱口，并须在液态沥青淹没火管后，才能点燃喷灯。
5. When the fixed blowtorch is used to heat the fire pipe of the asphalt tank, the chimney opening on the back wall of the asphalt tank shall be opened first, and the burner can be ignited only after the fire pipe is submerged by liquid asphalt.
6加热喷灯的火焰过大或扩散蔓延时，应立即关闭喷灯，让多余的燃油烧尽后再行使用。
6. When the flame of heating blowtorch is too large or diffused, the burner should be turned off immediately and the surplus fuel should be burned out before use.
7在吸油管及近料口尚未封闭时，以及在热态沥青的情况下，不得使用喷灯。
7 blowtorch shall not be used when the oil suction pipe and near material opening are not closed, and in the case of hot asphalt.
8手提喷灯点燃时，不允许接近易燃品。
8. When the portable blowtorch is ignited, it is not allowed to get close to inflammables.
9吸油作业时，要选好停车位置，车身停放平稳，各出口阀门应处于关闭位置。注意指针指示，及时停吸，防止沥青外溢。
9. During oil absorption operation, the parking position should be selected, the car body should be parked stably, and each outlet valve should be in the closed position. Pay attention to the pointer indication and stop suction in time to prevent asphalt overflow.
10 满载沥青运行时，应中速形势。遇有弯道、斜坡时，应提前减速，尽量避免紧急制动。
10. When running with full load of asphalt, the medium speed situation shall be adopted. In case of curve and slope, deceleration shall be conducted in advance and emergency braking shall be avoided as far as possible.
11 喷撒作业时，在喷撒方向10米内不得站人。
11 during spraying operation, no one shall stand within 10 meters of spraying direction.
12 喷撒时，应按引导线指示的方向，调整好车速平稳前进，不得任意摆动，猛转方向盘和变速。
12. When spraying, the speed should be adjusted according to the direction indicated by the guide line, and the vehicle should move forward smoothly. It is not allowed to swing arbitrarily, turn the steering wheel violently and change speed.
13 沥青撒布车在行使时，严禁使用加热系统。
13. When the asphalt distributor is running, it is strictly forbidden to use the heating system.
14 撒布作业结束后，应使用沥青泵将管道内的残余沥青吸回沥青箱内。
14 after the spraying operation, the residual asphalt in the pipeline should be sucked back to the asphalt box by using the asphalt pump.
15 完成当天后，要加热喷嘴，及时清除机上各部残留的沥青，进行例保工作。
15 days after completion, the nozzle should be heated, and the residual asphalt on each part of the machine should be removed in time for routine maintenance.
以上是关于水泥撒布车操作流程的相关内容介绍，希望可以帮到大家！
The above is about the cement spreader operation process related content introduction, hope to help you!
公司地址：济南市槐荫区经一路273号群盛华城2号楼1-404
公司名称：山东途畅路桥工程有限公司 
备案号：